SPECS:
DESIGN: PMDD
VOLTAGE: 12 VOLT
ROTATION; CCW
TEETH: 8
KILOWATTS:
REPLACES??
AQUA POWER 2840, JOHNSON ELECTRIC 0814240, OUTBOARD MARINE CORP (OMC) 387094, 395207, 585062, 586288, 777693, 778992, PRESTOLITE 20513501TBA, 46-2387, MJL4005, UNITED TECHNOLOGIES 0814240-M030SM, 0814240MO30SM, 4786240-M030SM, 4786240MO30SM, SM08142, SM47862, SMH12C42
USED ON
EVINRUDE 1977-1995
JOHNSON 1977-1992
A starter (also self-starter, cranking motor, or starter motor) is a device used to rotate (crank) an internal-combustion engine so as to initiate the engine's operation under its own power. Starters can be electric, pneumatic, or hydraulic. In the case of very large engines, the starter can even be another internal-combustion engine.
Internal combustion engines are feedback systems, which, once started, rely on the inertia from each cycle to initiate the next cycle. In a four-stroke engine, the third stroke releases energy from the fuel, powering the fourth (exhaust) stroke and also the first two (intake, compression) strokes of the next cycle, as well as powering the engine's external load. To start the first cycle at the beginning of any particular session, the first two strokes must be powered in some other way than from the engine itself. The starter motor is used for this purpose and it is not required once the engine starts running and its feedback loop becomes self-sustaining.
Starter installation
Clean the armature and external drive mechanism with gasoline first. After cleaning, check whether the drive is flexible; when installing, apply graphite grease between the friction plates of the friction clutch, and apply organic oil to the threaded filament part; the starter is installed on the engine, and the distance between the end face of the driving gear and the plane of the flywheel is 3 5 mm is appropriate to ensure that the gears mesh correctly.
Fault check
The starter often has failures and phenomena that cannot rotate or rotate slowly. In this case, check the following aspects:
1. The battery has no electricity or the electricity is weak, so the starter cannot rotate or rotate slowly.
2. The starter thread is loose or off, and the switch or adsorption switch fails.
3. The brush is worn out or the brush surface is not correct, and the spring is weak, resulting in poor contact of the rectifier.
4. Excitation coil or armature coil is short-circuited or disconnected.
5. The rectifier is fouled and the mica sheet is protruding, causing poor contact between the brush and the rectifier.
Organization maintenance
In the process of starting the engine, the starter must draw in 344~400Ah from the battery. Therefore, in order to prevent the battery from over-current or damage, the starting time should not exceed 5s. In winter, it is easy to start difficult to start. Multiple starting times should not be too long, and appropriate intervals should be left in each starting.
Unit Type: Starter
Part Type: UNIT
Voltage: 12
Rotation: CCW
Teeth: 8
Starter Type: PMDD
Brief: OMC 150-235 HP
API MARINE: MJL4005, MOT2004
ARCO MARINE: 5373
ARROWHEAD: SAB0003
CARGO: 110645
J & N: 410-21006
JOHNSON ELECTRIC: 814240
LESTER: 5294, 5709
OMC: 387094, 395207, 585062, 586288
PRESTOLITE: 46-2387, MJL4005
SIERRA MARINE: 18-5600, 18-5640
UNITED TECH: 0814240-M030SM, 4786240-M030SM, SM08142, SM47862, SMH12C42
WAI: 2-2074-UT
MAKE TYPE MODEL YEAR ENGINE
EVINRUDE Engines - Marine Outboard E150 (Older Models) 1977-1979 2.5L-149.4ci-150 HP
EVINRUDE Engines - Marine Outboard E150CX 1988-1991 2.5L-149.4ci-150 HP
EVINRUDE Engines - Marine Outboard E150STL 1984-1991 2.5L-149.4ci-150 HP
EVINRUDE Engines - Marine Outboard E150TL 1984-1991 2.5L-149.4ci-150 HP
EVINRUDE Engines - Marine Outboard E150TRL 1980-1983 2.5L-149.4ci-150 HP
EVINRUDE Engines - Marine Outboard E150TRX 1980-1983 2.5L-149.4ci-150 HP
EVINRUDE Engines - Marine Outboard E150TX 1984-1991 2.5L-149.4ci-150 HP
EVINRUDE Engines - Marine Outboard E155WTX 1985-1995 2.5L-149.4ci-155 HP
EVINRUDE Engines - Marine Outboard E175 (Older Models) 1977-1979 2.5L-149.4ci-175 HP
EVINRUDE Engines - Marine Outboard E175STL 1990-1991 2.6L-160.3ci-175 HP
EVINRUDE Engines - Marine Outboard E175TL 1986-1989 2.6L-160.3ci-175 HP
EVINRUDE Engines - Marine Outboard E175TRL 1980-1983 2.5L-149.4ci-175 HP
EVINRUDE Engines - Marine Outboard E175TRX 1980-1983 2.5L-149.4ci-175 HP
EVINRUDE Engines - Marine Outboard E175TX 1985-1991 2.6L-160.3ci-175 HP
EVINRUDE Engines - Marine Outboard E185TL 1984-1985 2.5L-149.4ci-185 HP
EVINRUDE Engines - Marine Outboard E185TX 1984-1985 2.5L-149.4ci-185 HP
EVINRUDE Engines - Marine Outboard E200 (Older Models) 1977-1979 2.5L-149.4ci-200 HP
EVINRUDE Engines - Marine Outboard E200STL 1986 2.7L-160.3ci-200 HP
EVINRUDE Engines - Marine Outboard E200STL 1987 2.7L-160.3ci-200 HP
EVINRUDE Engines - Marine Outboard E200TRL 1980-1983 2.5L-149.4ci-200 HP
EVINRUDE Engines - Marine Outboard E200TRX 1980-1983 2.5L-149.4ci-200 HP
EVINRUDE Engines - Marine Outboard E200TX 1987 2.7L-160.3ci-200 HP
EVINRUDE Engines - Marine Outboard E225 (Older Models) 1977-1979 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225CL 1987 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225CX 1987 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225PL 1987 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225PTL 1986 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225PTX 1986 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225PX 1987 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225TL 1986-1987 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E225TX 1986-1987 2.7L-160.3ci-225 HP
EVINRUDE Engines - Marine Outboard E235 (Older Models) 1977-1979 2.7L-160.3ci-235 HP
EVINRUDE Engines - Marine Outboard E235STL 1984-1985 2.7L-160.3ci-235 HP
EVINRUDE Engines - Marine Outboard E235TL 1984-1985 2.7L-160.3ci-235 HP
EVINRUDE Engines - Marine Outboard E235TRL 1980-1983 2.7L-160.3ci-235 HP
EVINRUDE Engines - Marine Outboard E235TRX 1980-1983 2.7L-160.3ci-235 HP
EVINRUDE Engines - Marine Outboard E235TX 1984-1985 2.7L-160.3ci-235 HP
JOHNSON Engines - Marine Outboard 150 (Older Models) 1977-1979 149.4ci - 150 HP
JOHNSON Engines - Marine Outboard 150CX 1988-1991 149.4ci - 150 HP
JOHNSON Engines - Marine Outboard 150STL 1984-1990 149.4ci - 150 HP
JOHNSON Engines - Marine Outboard 150TL 1980-1991 149.4ci - 150 HP
JOHNSON Engines - Marine Outboard 150TRL 1983 149.4ci - 150 HP
JOHNSON Engines - Marine Outboard 150TRX 1983 149.4ci - 150 HP
JOHNSON Engines - Marine Outboard 150TX 1980-1991 149.4ci - 150 HP
JOHNSON Engines - Marine Outboard 155CTL 1987 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155CWTX 1987 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTL 1985-1986 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTL 1990-1992 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTLM 1988 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTLZ 1989 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTX 1985-1986 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTX 1990-1992 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTXM 1988 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 155WTXZ 1989 149.4ci - 155 HP
JOHNSON Engines - Marine Outboard 175 (Older Models) 1977-1979 149.4ci - 175 HP
JOHNSON Engines - Marine Outboard 175STL 1990-1991 160.3ci - 175 HP
JOHNSON Engines - Marine Outboard 175TL 1980-1982 149.4ci - 175 HP
JOHNSON Engines - Marine Outboard 175TL 1986-1989 160.3ci - 175 HP
JOHNSON Engines - Marine Outboard 175TRL/175TRX 1983 149.4ci - 175 HP
JOHNSON Engines - Marine Outboard 175TX 1980-1981 149.4ci - 175 HP
JOHNSON Engines - Marine Outboard 175TX 1986-1990 160.3ci - 175 HP
JOHNSON Engines - Marine Outboard 175TX 1991 160.3ci - 175 HP
JOHNSON Engines - Marine Outboard 175TXL 1982 149.4ci - 175 HP
JOHNSON Engines - Marine Outboard 185TL 1984-1985 149.4ci - 185 HP
JOHNSON Engines - Marine Outboard 185TX 1984-1985 149.4ci - 185 HP
JOHNSON Engines - Marine Outboard 200 (Older Models) 1977-1979 149.4ci - 200 HP
JOHNSON Engines - Marine Outboard 200STL 1986-1987 160.3ci - 200 HP
JOHNSON Engines - Marine Outboard 200TL 1980-1981 149.4ci - 200 HP
JOHNSON Engines - Marine Outboard 200TL 1982 149.4ci - 200 HP
JOHNSON Engines - Marine Outboard 200TRL 1983 149.4ci - 200 HP
JOHNSON Engines - Marine Outboard 200TRX 1983 149.4ci - 200 HP
JOHNSON Engines - Marine Outboard 200TX 1980-1981 149.4ci - 200 HP
JOHNSON Engines - Marine Outboard 200TXL 1982 149.4ci - 200 HP
JOHNSON Engines - Marine Outboard 225 (Older Models) 1977-1979 160.3ci - 225 HP
JOHNSON Engines - Marine Outboard 225CL 1987 165.0ci - 225 HP
JOHNSON Engines - Marine Outboard 225CX 1987 165.0ci - 225 HP
JOHNSON Engines - Marine Outboard 225PL 1987 165.0ci - 225 HP
JOHNSON Engines - Marine Outboard 225PTL 1986 160.3ci - 225 HP
JOHNSON Engines - Marine Outboard 225PTX 1986 160.3ci - 225 HP
JOHNSON Engines - Marine Outboard 225PX 1987 165.0ci - 225 HP
JOHNSON Engines - Marine Outboard 225TL 1986-1987 160.3ci - 225 HP
JOHNSON Engines - Marine Outboard 225TX 1986-1987 160.3ci - 225 HP
JOHNSON Engines - Marine Outboard 235STL 1984-1985 160.3ci - 235 HP
JOHNSON Engines - Marine Outboard 235TL 1980-1985 160.3ci - 235 HP
JOHNSON Engines - Marine Outboard 235TRL 1983 160.3ci - 235 HP
JOHNSON Engines - Marine Outboard 235TRX 1983 160.3ci - 235 HP
JOHNSON Engines - Marine Outboard 235TX 1980-1985 160.3ci - 235 HP
JOHNSON Engines - Marine Outboard 235TXL 1982 160.3ci - 235 HP
Item Specifics | |
---|---|
Brand | CCIYU |
Manufacturer Part Number | AP051166A |
Interchange Part Number | MJL4005 MOT2004 5373 SAB0003 110645 410-21006 |
Other Part Number | 5294 5709 387094 395207 585062 586288 46-2387 |
Reference Part Number | 0814240-M030SM 814240 MJL4005 18-5600 18-5640 |
Superseded Part Number | 4786240-M030SM SM08142 SM47862 SMH12C42 2-2074-UT |
Compatibility | Starter For OMC JOHNSON EVINRUDE 150 155 175 185 200 |
Warranty | 1 Year |
Fitment Type | Direct Replacement |
Surface Finish | New Quality |
Voltage | 12 |
Rotation | CCW |
Teeth | 8 |
Starter Type | PMDD |
Part Type | Starter |
Weight | 3.86kg |
Package | 30.00(L) * 10.20(W) * 10.00(H) |
Number of Pieces | 1 |
Non-Domestic Product | No |
Custom Bundle | No |
Modified Item | No |
Position | Front |
Universal Fitment | No |
Universal Fitment | No |
WARNING : Cancer and Reproductive Harm - www.P65Warnings.ca.gov.
PayPal preferred.
Payments are expected within 7 days after the last winning auction is closed; Otherwise Unpaid Item Dispute will be filed with eBay.
ShippingAll domestic orders will be shipped via USPS, UPS or FedEx from our US warehouse and usually arrives to your door in about 3-5 business days.
We ship the package to your shipping address in eBay instead of the one in PayPal. Please tell us your shipping address if it is different from the one in eBay.
The tracking number will be given for the customer to check the shipping status online (registered or faster service only).
We are not responsible for any wrong or undeliverable addresses. Please verify and update your shipping address on eBay during checkout.
Returns 1.All of our brand new items come with a 60-Days money-back guarantee. 2.We define the item as defective only if it doesn't function as described, It is the buyer's responsibility to understand the item description before bidding. 3.We will replace the defective items, provided that they are in stock within the warranty period posted with the listing and the buyer return the original item and pay for the S&H cost for the replacement. 4.We will refund the purchase price if the replac ement is not available or buyer prefers a refund and send the original item back at his/her own cost. 5.Shipping& handling cost are not refundable. 6.Man-made damage by abuse or wrong operation is not covered by this warranty. 7.No product liability insurance is assumed. 8.Refunds will be credited within 5 to 7 business days of receiving the return. When we've received and processed the return, we will refund the applicable amount minus any Recovery Fees (See Details Below) for the amount you paid for the item(s), plus any applicable sales tax. Customer Services Q: How do I pay for my purchase? A: MY store accepts PayPal. Q: When will the item be shipped out? A: This item will be shipped with 2 business day once payment completed. Q: Where is my tracking number? A: Please log on your account, click "my eBay"-->"my summary", or open your email box and find the shipping notification email. Q: How do I return an item? A: My tore accepts returns. Items must be returned within 60 days. Refunds will be given as money back. Please contact our customer service before you return an item.DESCRIPTION PAYMENT SHIPPING RETURN POLICY CONTACT US |
Shop Category Store Home
Catalytic Converter
Car Floor Mats
Fuel Shut Off Solenoid
Oil Cooler
Strut Tie Bar
Vacuum pump
Tire Pressure Gauge
Boost Pressure Gauge
Starter
Alternator
Power Steering Rack
Sensor
Transmission Kit
Relay Solenoid
Engine Mount
Voltage Rectifier Regulator
oil hose line
Truck Bed Mat
Other Hot Item
|
New Starter For 1977-1992 Johnson Outboard 1980-1992Evinrude Outboard SMH12C42
SPECS:
REPLACES??
USED ON
A starter (also self-starter, cranking motor, or starter motor) is a device used to rotate (crank) an internal-combustion engine so as to initiate the engine's operation under its own power. Starters can be electric, pneumatic, or hydraulic. In the case of very large engines, the starter can even be another internal-combustion engine. Internal combustion engines are feedback systems, which, once started, rely on the inertia from each cycle to initiate the next cycle. In a four-stroke engine, the third stroke releases energy from the fuel, powering the fourth (exhaust) stroke and also the first two (intake, compression) strokes of the next cycle, as well as powering the engine's external load. To start the first cycle at the beginning of any particular session, the first two strokes must be powered in some other way than from the engine itself. The starter motor is used for this purpose and it is not required once the engine starts running and its feedback loop becomes self-sustaining.
Starter installation
Fault check 1. The battery has no electricity or the electricity is weak, so the starter cannot rotate or rotate slowly. 2. The starter thread is loose or off, and the switch or adsorption switch fails. 3. The brush is worn out or the brush surface is not correct, and the spring is weak, resulting in poor contact of the rectifier. 4. Excitation coil or armature coil is short-circuited or disconnected. 5. The rectifier is fouled and the mica sheet is protruding, causing poor contact between the brush and the rectifier. Organization maintenance
Unit Type: Starter
API MARINE: MJL4005, MOT2004
MAKE TYPE MODEL YEAR ENGINE JOHNSON Engines - Marine Outboard 150TX 1980-1991 149.4ci - 150 HP WARNING : Cancer and Reproductive Harm - www.P65Warnings.ca.gov. PayPal preferred. Payments are expected within 7 days after the last winning auction is closed; Otherwise Unpaid Item Dispute will be filed with eBay. ShippingAll domestic orders will be shipped via USPS, UPS or FedEx from our US warehouse and usually arrives to your door in about 3-5 business days. We ship the package to your shipping address in eBay instead of the one in PayPal. Please tell us your shipping address if it is different from the one in eBay. The tracking number will be given for the customer to check the shipping status online (registered or faster service only). We are not responsible for any wrong or undeliverable addresses. Please verify and update your shipping address on eBay during checkout. Returns 1.All of our brand new items come with a 60-Days money-back guarantee. 2.We define the item as defective only if it doesn't function as described, It is the buyer's responsibility to understand the item description before bidding. 3.We will replace the defective items, provided that they are in stock within the warranty period posted with the listing and the buyer return the original item and pay for the S&H cost for the replacement. 4.We will refund the purchase price if the replac ement is not available or buyer prefers a refund and send the original item back at his/her own cost. 5.Shipping& handling cost are not refundable. 6.Man-made damage by abuse or wrong operation is not covered by this warranty. 7.No product liability insurance is assumed. 8.Refunds will be credited within 5 to 7 business days of receiving the return. When we've received and processed the return, we will refund the applicable amount minus any Recovery Fees (See Details Below) for the amount you paid for the item(s), plus any applicable sales tax. Customer Services Q: How do I pay for my purchase? A: MY store accepts PayPal. Q: When will the item be shipped out? A: This item will be shipped with 2 business day once payment completed. Q: Where is my tracking number? A: Please log on your account, click "my eBay"-->"my summary", or open your email box and find the shipping notification email. Q: How do I return an item? A: My tore accepts returns. Items must be returned within 60 days. Refunds will be given as money back. Please contact our customer service before you return an item.All rights reserved. |